2021 Ford Bronco: What to check before buying
Owners have filed 798 complaints with NHTSA about this car, most about the electrical, transmission, and engine. The 9 checks below target those problems, in the order you would do them at the car.
2021- Owner complaints
- 798
- Recalls
- 30
- Crashes reported
- 20
- 19 injuries
Your inspection sheet
Tick items off on your phone at the car, or print it. Ticks stay on this device.
0/9 checked
2021 Ford Bronco: inspection sheet
Paperwork and questions
Before you go, or before you touch the car0/3
Cold start, engine bay, and underside
Ask the seller not to warm the car up first0/4
Test drive
At least 20 minutes, with some highway0/2
These checks are specific to this model year. For tires, body panels, fluids, and the other basics every used car needs, use the general inspection guide.
Which Bronco is it?
EPA figures for each version of the 2021 Ford Bronco. Use them to confirm you are looking at the version that was advertised, and as a yardstick on the test drive.
| Version | Drive | EPA rating |
|---|---|---|
| 2.3L 4-cyl | 4WD | 21 mpg |
| 2.7L 6-cyl | 4WD | 19 mpg |
- The 2021 Ford Bronco was sold in two versions. Confirm which one this is from the window sticker, the engine cover, or the VIN report before you compare prices.
- Reset the trip computer at the start of the drive. A Bronco that averages well under the EPA 19 mpg combined on a mixed route may have an engine or tire problem.
Check the odometer against these mileages
Owners report these failures starting around the mileages below. A car inside one of these ranges deserves a closer look at that part, or records showing it was already fixed.
Early catastrophic engine failure
625–7,000 miles
Rear shock leaks and detachment
16,000–50,000 miles
Rear differential failure
27,000–60,600 miles
Water pump coolant leaks
52,000–79,000 miles
Automatic transmission failure
64,000–86,000 miles
Why these checks: what owners reported
NHTSA complaints for the 2021 Ford Bronco, grouped by the part owners named. Open a row to read what goes wrong.
Electrical1683 crashes
Sudden, total power loss while driving is the most common report. Engines shut off at highway speed, and the hazard lights, steering, and brakes go dead. Some cars cannot be shifted into neutral to push them clear. At startup, many cars flash every light, cycle error messages, and refuse to crank. Several of these episodes end in smoke or fire under the hood, and 7 complaints involve fire. Batteries, alternators, and starters get replaced, and some owners say the stalling comes back even after battery and software work under a recall.
Transmission135No crashes
Automatic transmission failure is the main pattern. Most of these failures come soon after the 60,000-mile powertrain warranty ends. Symptoms include slipping, shudder, harsh shifts from first to second, sudden drops into neutral with the engine racing, and cars that will not move forward or back. Dealers quote $8K to $13,000 for a replacement. Rear differential failures also appear, with grinding or binding in sharp turns, and some start under 30,000 miles. Water pumps crack and leak coolant, and several owners report replacing them more than once.
Engine1081 crash
Sudden shutdowns without warning, often at highway speed, lead these reports, and the car usually will not restart. A cluster describes catastrophic failure in the first few thousand miles, with knocking, oil loss, or a low oil pressure alert, followed by full engine replacement. Stalling from failed fuel pumps and low fuel pressure also comes up, sometimes with the car stuck at the dealer waiting for parts. Some owners report a rough, surging idle that worsens with miles. One fire started in the engine bay just after the car was parked.
Stalling and loss of power while driving lead these reports. Causes named by dealers include failed water pumps, drained or failed batteries, and a failed turbocharger that limited speed. Water pump failures cluster between 61,000 and 75,000 miles. Owners also report fuel odor through the vents, sputtering after refueling, and passenger-side vents that stop blowing hot air. One car was destroyed by an engine fire at 142,000 miles, which the dealer blamed on a faulty serpentine belt.
Brakes1055 crashes
The brake pedal suddenly turns rock hard and the car barely slows, sometimes at walking speed and sometimes in traffic. Several reports trace this to a cracked or detached vacuum hose or a failed brake booster, often with a hissing sound or a red brake warning light. These complaints include 5 crashes and 4 injuries. Some owners describe a delay before the car stops or brakes that fail during a pre-collision alert. Many say they were told a brake recall repair was on hold because parts were not yet available.
Fuel system491 crash
Most complaints here are not failures. Owners received a fuel system recall notice and say the repair part is still unavailable from the dealer. Where failures do appear, they include hesitation or near-stalling after refueling, a gasoline smell around the car, check engine lights, and failed fuel injectors. One car stalled in traffic from a failed fuel pump at 1449 miles. Two reports involve fires at the front of the vehicle, one in a crash that caused serious injuries.
Suspension39No crashes
Rear shocks leak or lose their external fluid reservoir, which can simply fall off. With the shocks gone, the car bounces and kicks over normal bumps at highway speed, and one shock came loose and struck the car behind. Reported failures fall mostly between 16,000 and 50,000 miles, and some recur after repair. Owners also describe screeching or scraping from the rear end in turns and when stopping, along with CV axle, control arm, and strut failures. Some say the dealer told them a recall remedy was not yet ready.
Steering17No crashes
When the car loses electrical power, the steering locks and the car will not stay in neutral. That leaves drivers stuck in traffic or unable to be pushed clear. Separately, owners report shudder, grabbing, lurching, or a loud moan during low-speed turns, often traced to the drivetrain rather than the steering itself. Rear-end instability over bumps above 50 mph is also reported. In one case a dealer found the steering gear detaching at about 77,000 miles.
Airbags117 crashes
Failure to deploy in serious collisions is the main complaint, including side impacts and high-speed crashes. These reports include 7 crashes and 10 injuries, among them fractures and neck and back injuries. The opposite problem also appears: a steering wheel bag fired after a pothole, and at least 6 bags deployed in a minor deer strike, totaling the car. Other owners say they received a recall notice for this system but were told repair parts were not yet available.
In owners' own words
Excerpts from complaints Bronco owners filed with NHTSA, as written. Listen for the same symptoms on your test drive.
I have been getting a message that my blind spot and cross traffic alert deactivated because trailer is attached. I have never had a trailer attached but do have a trailer hitch- the dealer said Ford refuses to pay to have it fixed because the bumper to bumper warranty is out. the car has been garaged and has only 9,000 miles on it. This is a safety issue that I think they should cover as I have no blind spot or cross traffic warnings.
Filed with NHTSA, August 2025
While at stop light, engine shut off (auto start-stop). Wouldn't restart, car would not move, automatically went into park, wouldn't go into neutral to be moved, and was stuck. Had to manually release the vehicle into neutral to be moved. Battery was completely dead, replacement solved the issue. Battery was less than 2 years old. Approx. 50k miles.
Filed with NHTSA, February 2024
My wife's 2021 Ford Bronco Sport has had a complete transmission failure and the vehicle has less than 75,000 miles on it. We're told by Ford that the Powertrain warranty ends after 60,000 miles. This has been a disaster for us as we're paying a note on a vehicle that we cannot drive because it will cost $10-11K to repair. I've never owned a vehicle that has had so many problems in my life.
Filed with NHTSA, October 2025
The Vehicle was serviced as normal, everything came back in good shape. A few days later the transmission began to slip. The vehicle was taken back to the dealership where I was told that the Torque Converter was broken and the vehicle would require a full transmission replacement costing a total of $8K. The vehicle currently has 102,357 Miles on it.
Filed with NHTSA, September 2025
First time the engine lights came on and turned off the car could not restart, needed a new engine the first engine had 830 miles. Second time car stalled and the car would not start they replaced the engine again this time that engine had about 1,200 miles. Third time the car did the same thing with about 1,400 miles. All three times I was driving on Busy roads almost got hit all three times. Dealership did not give me any paperwork
Filed with NHTSA, January 2022
The water pump has been replaced twice already and the water pump needs to be replaced again at 105,000 miles. This will be the fourth water pump this vehicle has. The originally came with, two replacements, and now the one that it needs because it is leaking like the previous three. The turbo charger failed and was burning oil. That was replaced. A month later it is back at the dealership being replaced again
Filed with NHTSA, April 2025
When coming to a stop and pressing on the breaks it periodically will make s sound and then there is about a 2O SEC DELAY before coming to complete stop. If I am driving downhill the delay is longer. This scares my since I drive over 100 miles a day for work. I have reached out to FORD and the manufacture and they still do not have a fix to the issue.
Filed with NHTSA, August 2022
Upon starting the vehicle, brakes were extremely hard to press down and barely responded. A great deal of effort was needed to bring the car to a stop at below 5 miles an hour. If I had been driving instead of pulling out of a parking lot, this could have caused a significant accident.
Filed with NHTSA, August 2025
How the 2021 compares with other Bronco years
Complaints for this year next to the average for the other model years, area by area.
The 2021 has the most owner complaints of the 5 Bronco years we cover, about 3.2 times the average of the others. Newer years have had less time to collect complaints, so compare like with like.
- Electrical16834
- Transmission13531
- Engine10818
- Brakes10520
- Fuel system4916
- Suspension3911
Where the 2021 fits in the Bronco's history
Redesigns and mid-cycle updates change what can go wrong.
The 2021 is the first model year of the Bronco's sixth generation (2021–2023). First years of a redesign often carry teething problems that Ford fixes in later years, so the checks above matter more than usual.
Ford updated the Bronco for 2023, so a 2021 does not have those changes.
What changed for 2023 (not on a 2021)
- New Raptor trim level with enhanced performance and features
Should you avoid the first year of a redesign? See the 45-car study.
Recalls to confirm (30)
Recall repairs are free at any Ford dealer, but the seller may never have had them done. Check each campaign number against the VIN.
25V888000Backup cameraDec 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously repaired incorrectly under recall number 23V165. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility.".
Risk: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Fix: Dealer will update the SYNC module software ,free of charge. Owner notification letters were mailed January 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C72. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 30, 2026.
25V721000SeatsOct 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Risk: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Fix: Dealers will replace the pivot links and bolts, free of charge. Interim letters, notifying owners of the safety risk, were mailed November 6, 2025. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.
25V685000EquipmentOct 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Risk: An electrical short circuit can increase the risk of a fire.
Fix: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated February 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
25V467000Fuel systemJul 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Risk: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Fix: Dealers will update the engine control software. and replace the high pressure fuel rail assembly and the fuel injector ,free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
25V455000Fuel systemJul 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Risk: An engine stall increases the risk of a crash.
Fix: The remedy is under development. Interim notification letters notifying owners of the safety risk were mailed July 16, 2025. Second letters will be sent once the remedy is available, anticipated March 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
25V442000Backup cameraJun 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
25V315000Backup cameraMay 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Fix: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
25V312000Backup cameraMay 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were repaired incorrectly under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility.".
Risk: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Fix: Dealers will update SYNC module software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C14.
25V165000Fuel systemMar 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Fix: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
25V158000TransmissionMar 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
25V025000SuspensionJan 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Risk: An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.
Fix: Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.
25V019000ElectricalJan 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Risk: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
24V635000EngineAug 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Fix: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
24V267000ElectricalApr 2024
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
23V598000Backup cameraAug 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Risk: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Fix: Dealers will replace the rearview camera, and update the software and wiring as necessary, free of charge. Owner notification letters were mailed November 20, 2023 to Lincoln owners. Ford vehicle owners notification letters were mailed March 4, 2024. Ford remedy parts are anticipated 2nd Quarter 2024. Ford's number for this recall is 23S48.
23V358000Seat beltsMay 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection.".
Risk: Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.
Fix: Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.
23V165000Backup cameraMar 2023
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously remedied under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility.".
Risk: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Fix: The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 28, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C05.
22V928000AirbagsDec 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The right or left side impact sensors may not be properly secured to the vehicle.
Risk: An improperly secured side impact sensor may cause the air bags to unintentionally deploy, or not to deploy as intended, increasing the risk of injury in a crash.
Fix: Dealers will inspect the side impact sensor attachments and repair, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S77.
22V859000Fuel systemNov 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Fix: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
22V825000Backup cameraNov 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with rearview camera systems and 8-inch screen displays. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility.".
Risk: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.
Fix: The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 25, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C27.
22V411000Door latches and locksJun 2022
Ford Motor Company (Ford) is recalling certain four-door 2021-2022 Bronco vehicles. The passenger-side rear door may be opened from inside of the vehicle when the child safety lock is in the "ON" position.
Risk: A malfunctioning child safety lock increases the risk of injury to a child occupant.
Fix: Dealers will inspect the passenger-side child safety locks door child safety lock and latch, and replace them, if necessary, free of charge. Owner notification letters were mailed June 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S44.
22V191000EngineMar 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
Risk: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Fix: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
21V982000Automatic emergency brakingDec 2021
Ford Motor Company (Ford) is recalling certain 2021 Ranger and Bronco vehicles. The cruise control radar module was misaligned during production.
Risk: A misaligned radar module may prevent the vehicle from maintaining a safe distance from other vehicles when adaptive cruise control is active. In addition, the automatic emergency braking (AEB) system may react slowly, or not react at all, during a pre-collision assist braking event. Any of these scenarios can increase the risk of a crash.
Fix: Dealers will adjust the angle of the cruise control radar module, free of charge. Owner notification letters were mailed January 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S52.
21V922000BrakesNov 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems.".
Risk: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Fix: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.
21V809000Wipers and visibilityOct 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The moonroof glass may not have been bonded correctly to the moonroof frame, which could result in the glass panel detaching from the vehicle.
Risk: A detached glass panel can become a road hazard, and increase the risk of a crash or injury.
Fix: Dealers will inspect the moonroof glass date code and replace the glass, if necessary, free of charge. Owner notification letters were mailed November 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S46.
21V770000AirbagsOct 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco vehicles. During passenger air bag deployment, an air bag vent could open prematurely and result in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection.".
Risk: Improper air bag deployment increases the risk of injury during a crash.
Fix: Dealers will replace the passenger air bag, free of charge. An interim owner notification letter was mailed on November 24, 2021. A second notice announcing the remedy is available was sent on July 8, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C23.
21V625000Fuel systemAug 2021
Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.
Risk: An engine stall increases the risk of a crash.
Fix: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.
21V075000SuspensionFeb 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The rear suspension subframe assembly may have loose or missing bolts.
Risk: Loose or missing bolts may affect the vehicle's handling and control, increasing the risk of a crash. It could also reduce the vehicle's performance in a rear impact crash, increasing the risk of injury.
Fix: Ford will notify owners, and dealers will inspect the rear suspension bolts, and secure or replace the bolts, as necessary, free of charge. The recall began March 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S04.
21V074000SuspensionFeb 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. These vehicles may have been produced with incorrect front lower control arms.
Risk: An incorrect lower control arm may affect vehicle handling and control, increasing the risk of a rollover crash.
Fix: Ford will notify owners, and dealers will inspect and replace the front lower control arms, if necessary, free of charge. The recall began April 9, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S03.
21V011000TransmissionJan 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.
Risk: If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.
Fix: Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.
Also looking at these instead of a Bronco?
Cars shoppers compare with the Ford Bronco, with their own 2021 checklists.
2021 owner complaints, side by side
- Toyota 4Runner31
- Land Rover Defender 11032
- Chevrolet Blazer104
- Jeep Grand Cherokee427
- Volkswagen Atlas540
- 2021 Ford Bronco798
- Jeep Wrangler826
